Austin Air Companie Blog : Archive for the ‘No Technicians’ Category

R22 Freon Production Ban Timeline 2016

Tuesday, March 22nd, 2016

R22 Freon, the chemical coolant used in home air conditioners since the 1960’s is marking it’s final seasons until it will no longer be produced. The chart graphic above shows the year and the amount of R22 Freon allowed to be produced for that given year until January 1, 2020 when no more R22 Freon will be produced beyond that point. The production limits are set and controlled by the EPA and can be further changed at any time. The chart reflects the last Rule Change for production limits set by the EPA in October 2014.

There will likely be small amounts available after 2020 as older reclaimed R22 refrigerant is turned in and sent off to reclaim centers that clean it of contaminants and resell it as virgin quality once it has been cleaned of impurities. However, prices will likely be very high and very likely strict limits will be placed on how much can be bought at one time.

Once these strict limits are placed on how much can be bought it is very likely in my opinion that system recharges will no longer exist. Home owners and businesses will be forced to fix the leak(s) or replace and upgrade the air conditioning equipment to R410a Puron refrigerant. It is in your best interest to make plans now to either fix your AC system refrigerant leaks or come up with a plan to replace your AC system to the newer R410a refrigerant.

R410a is the replacement refrigerant to R22 Freon. While it is the newer standard, it isn’t all that new. It has just taken a long time for it to gain acceptance because the pressures are higher and better service practices are required when working with it.

Because of these requirements certain HVAC companies held off making the change, I think partly due to ignorance, partly due to laziness and even more likely the cost forced onto you the consumer because it’s in your best interest to replace the whole AC system when changing over instead of just one piece of the system. Taking short cuts with an R410a system is less forgiving than with an R22 Freon system.

Like I said above R410a Puron isn’t new. It became available in the mid 90’s. It’s pressures are higher and the equipment that uses it had to go thru special processes to ensure the higher pressures could be handled appropriately. Additionally it requires the use of synthetic oil, where as most older R22 systems today use mineral oil. Your R22 Freon system will not work with R410a Puron. I’m sure you might have been thinking that. There’s more differences between the two systems than oil types and pressures. There’s also refrigerant flow which relates to capacity of the system. Your current AC simply will not work to recharge an R22 Freon system with R410a Puron. It will not work.

Remember, the makings of a scam is something that is “too good to be true.” Be smart about it, you will be glad you did.

If you would like to know more about this subject you can watch several videos I’ve made on the subject as well as a lot of text on the subject since 2009. You can click the link below to open that page from my main website.

R22 Freon VS R410a Puron The Facts

I hope you have found this information before you made a costly mistake. I have installed as well as retrofitted countless systems over to the newer R410a refrigerant for years now. I’m sure I could do the same for you and your family.

Thank you for visiting with me today! I hope your day is a comfortable one.

About the author of this blog:

My name is Ray Austin. I am the owner and operator of Austin Air Companie, a HVAC Service Company serving Katy, Texas | Cypress, Texas and some surrounding areas. I am a Texas Licensed HVAC Contractor with over 20 years experience in Air Conditioning and Heating Systems. I hold an AOS degree in HVAC/R, EPA universally certified to handle any refrigerant and NATE certified in HVAC installations and repairs.

Austin Air Companie

832.475.6895

“Your home comfort from A to Z”

Air Conditioning | Controls | Heating | Zoning

For more information:

videos, tips and everything air conditioning and heating

for your home you can always visit me on my main website @

www.austinairco.com

Better Stuff. Done Right. On Time. Guaranteed.

Tags: AC coolant available, Freon Ban, freon leak fix, freon leak professional, freon leak repair specialist, Freon leak repairs, Freon Leaks, Freon problems, Freon recharge, Freon replacement, R22 Freon availability, R22 Freon phase out, R410a Freon, R410a Puron, R410a refrigerant leaks, R410a specialist
Posted in Air Conditioning, Air Conditioning Pro, Air Conditioning Specialist, Home Improvement, HVAC Contractor, No AC Salesmen, No Technicians, Professional AC Repair, R22 Freon & R410a Puron Leaks, Uncategorized, Working HVAC Contractor | Comments Off on R22 Freon Production Ban Timeline 2016

Air Conditioning Specialist

Sunday, March 20th, 2016

When your home has an air conditioning breakdown in Katy, Texas you pick up the phone and call an Air Conditioning Company to get it fixed. Because I am the owner of an Air Conditioning company serving the Katy area, I know that it’s not always this simple. If it was there likely wouldn’t be any need for the AC services that I offer.

Many times the need of an Air Conditioning Specialist in Katy, Texas and some surrounding areas is sometimes caused by the people who you have called in the past or maybe a previous owner of the home you purchased. To help you understand this a little better you have to realize that air conditioning and heating for your home is a system that on a national average lasts about 15 years if it’s installed properly the problems should be few. Because your HVAC system lasts so long (typically) the problems tend to develop slowly, unless the AC problems are made worse by those servicing your HVAC equipment.

Many AC companies get into the AC business by becoming “cleaning” companies or “maintenance” companies. You see the ads don’t you? Get your AC tuned up, get your AC checked. This doesn’t mean this isn’t a legitimate service. It is, but only if the service is done right.

Most companies use Technicians and due to the financial crisis in 2008 many good HVAC Technicians left the HVAC service industry. So in many cases this leads to you getting “hoodwinked”. Spin the AC technician roulette wheel, let me see what you win ok?

Did you know that 55% of Air Conditioning companies fail due to incompetence? I did a video on that a year ago and I’m in the process of making a new video to show how these things can effect you. Subscribe to my You Tube Channel so you don’t miss this special AC presentation. It should open your eyes just a little.

The HVAC business is highly technical and requires a certain amount of aptitude to perform it, not to mention continual learning. I didn’t become an Air Conditioning Specialist over night and I don’t really consider myself all that special other than the fact that I know that I have solved very complicated air conditioning problems in the past. Problems so bad in fact that the home owner was being led to believe they needed to replace a HVAC system that was only 2 1/2 years old. How is that for technical aptitude?

Replacing AC systems can solve your problems and in some cases that is the better option, but does this mean every time you have an AC problem you will just replace the HVAC system? I bet you have more money than you know what to do with.

Remember, when replacing an AC system “the devil is in the details”. Every major HVAC manufacturer makes multiple models, most of them are junk. A salesman is paid to sell you this junk most of the time. A free estimate is code word for “please send me a salesman”. The other part is service after the sale and the ability to repair the AC system when it breaks. Sure, you could say that talk is cheap right? Well I can help you prove it to yourself. You probably found me via a Google search, so do another search about complaints of any major HVAC brand, list the brand name in the search. You will see that I’m right. This is what I do for a living after all, why should I apologize for the truth?

If you are reading this after the fact and got taken advantage of by getting what you thought was a good deal and now have nothing but air conditioning problems I can come up with a solution for you. I hear air conditioning nightmares all the time, if you are living one don’t make it worse. Find a licensed HVAC contractor that knows what they are doing. It’s not uncommon for me to see a dozen or so of these kinds of calls a year. I’d say it’s pretty important to have an HVAC contractor install your new AC system that knows how to fix them when they break. Wouldn’t you?

There is no manufacture warranty for: improper installation or AC equipment purchased over the internet. Please choose your licensed HVAC contractor wisely. Look at the whole picture, look at the details of the job before you make any hasty decision and do not choose based on price alone. Otherwise you may have to resort to spending time and more money trying to find a solution. I could be that solution.

Realize that my definition of “solution” is to solve the problem without causing additional problems, otherwise you’re not problem solving and the solution is not a true solution.

Thank you for visiting with me today. I hope your day is a comfortable one!

About the author of this blog:

My name is Ray Austin. I am the owner and operator of Austin Air Companie, a HVAC Service Company serving Katy, Texas | Cypress, Texas | Richmond, Texas and some surrounding areas. I am a Texas Licensed HVAC Contractor with over 20 years experience in Air Conditioning and Heating Systems. I hold an AOS degree in HVAC/R, EPA universally certified to handle any refrigerant and NATE certified in HVAC installations and repairs.